Hyundai Santa Fe: Rear Door / Rear Door Window Glass. Repair procedures

Hyundai Santa Fe (TM) 2019-2025 Service Manual / Body (Interior and Exterior) / Rear Door / Rear Door Window Glass. Repair procedures

Replacement
1.
Remove the rear door trim.
(Refer to Rear door - " Rear door trim")
2.
Using a remover and separate the rear door belt outside weatherstrip (A).
3.
Loosen the rear door delta molding screws.
4.
Unscrew the rear door channel mounting nut and bolt loosely.
Tightening torque
Nut : 7.8 - 11.8 N.m (0.8 - 1.2 kgf.m, 5.8 - 8.7 lb-ft)
Bolt : 7.8 - 12.7 N.m (0.8 - 1.3Kgf.m, 5.8 - 9.4 lb-ft)

5.
Remove the rear door belt inside weatherstrip (A).
6.
Remove the plug hole (A).
7.
By operating the power window switch, pull down until the glass mounting bolt on plug hole is visible.
  
•
Be careful not to damage the glass surface.
8.
Loosen the mounting bolt and then pull out the rear door window glass (A) by tilting it sideways.
Tightening torque :
7.8 - 11.8 N.m (0.8 - 1.2 kgf.m, 5.8 - 8.7 lb-ft)

9.
To install, reverse removal procedure.
  
•
Make sure that the glass rolls up and down smoothly.
•
Adjust glass position as needed.
•
Make sure the door locks and opens properly.
•
Replace any damaged clips (or pin-type retainers).

    Rear Door Window Glass. Components and components location

    ..

    Rear Door Module. Components and components location

    ..

    Other information:

    Hyundai Santa Fe (TM) 2019-2025 Owner's Manual: Engine oil pressure warning light. Low fuel level warning light


    Engine oil pressure warning light This warning light illuminates: When the engine oil pressure is low. If the engine oil pressure is low: 1. Drive carefully to the nearest safe location and stop your vehicle. 2. Turn the engine off and check the engine oil level (For more details, refer to “Engine Oil” section in chapter 9)...

    Hyundai Santa Fe (TM) 2019-2025 Service Manual: Water Temperature Control Assembly. Repair procedures


    Removal and Installation    • Be careful not to damage the parts located under the vehicle (floor under cover, fuel filter, fuel tank and canister) when raising the vehicle using the lift...

    Categories

    Instrument panel overview

    1. Instrument cluster
    2. Driver’s front air bag
    3. Engine Start/Stop button
    4. Infotainment system
    5. Hazard warning lamp switch
    6. Climate control system
    7. Shift button
    8. ISG (Idle Stop and Go) button
    9. Auto Hold button
    10. Heated steering wheel button
    11. Drive mode button
    12. DBC (Downhill Brake Control) button
    13. Parking Safety button
    14. Parking/View button
    15. Air ventilation seat button
    16. Seat warmer
    17. Passenger’s front air bag
    18. Glove box
    19. Wireless charging system pad
    20. Cup holder
    21. AC inverter
    22. USB charger

    read more


     
    Copyright © 2025 www.hsafe4.com