Hyundai Santa Fe: Seat Belt Pretensioner / Seat Belt Pretensioner (BPT). Repair procedures

Hyundai Santa Fe (TM) 2019-2025 Service Manual / Restraint / Seat Belt Pretensioner / Seat Belt Pretensioner (BPT). Repair procedures

Removal
1.
Disconnect the battery negative cable, and wait for at least three minutes before beginning work.
2.
Remove the front anchor seat belt (A).

3.
Remove the center pillar lower trim.
(Refer to Body - "Center Pillar Trim")
4.
Remove the center pillar upper trim.
(Refer to Body - "Center Pillar Trim")
5.
After loosening the mounting bolt, then remove the front seat belt lower anchor (A).

6.
Disconnect the seat belt pretensioner connector (A) and then remove the seat belt pretensioner.

7.
Remove the seat belt pretensioner (A) after loosening the mouning bolts.

Installation
1.
Disconnect the battery negative cable and wait for at least three minutes.
2.
Install the seat belt pretensioner.
Tightening torque
Bolt (A) : 7.8 - 11.8 N.m (0.8 - 1.2 kgf.m, 5.8 - 8.7 lb-ft)
Bolt (B) : 39.2 - 53.9 N.m (4.0 - 5.5 kgf.m, 28.9 - 39.8 lb-ft)

3.
Install the front seat belt upper anchor bolt.
Tightening torque :
39.2 - 53.9 N.m (4.0 - 5.5 kgf.m, 28.9 - 39.8 lb-ft)

4.
Install the center pillar trim.
(Refer to Body - "Center Fillar Trim")
5.
Install the door scuff trim.
(Refer to Body - "Door Scuff Trim")
6.
Reconnect the battery negative cable.
7.
After installing the seat belt pretensioner, confirm proper system operation:
Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.

    Seat Belt Pretensioner (BPT). Components and components location

    ..

    Emergency Fastening Device (EFD). Description and operation

    Description The Emergency Fastening Device (EFD) operates at the same time with the Seat Belt Pretensioner when it satisifies the deployment condition after a collision...

    Other information:

    Hyundai Santa Fe (TM) 2019-2025 Owner's Manual: USB charger


    The USB charger is designed to recharge batteries of small size electrical devices using a USB cable. The electrical devices can be recharged when the Engine Start/Stop button is in the ACC or ON (or START) position. The battery charging state may be monitored on the electrical device...

    Hyundai Santa Fe (TM) 2019-2025 Owner's Manual: Seat belt safety precautions


    Always fasten your seat belt and make sure all passengers have fastened their seat belts before starting any trip. Air bags are designed to supplement the seat belt as an additional safety device, but they are not a substitute. Most states require all occupants of a vehicle to wear seat belts...

    Categories

    Power adjustment

    The front seat can be adjusted by using the control switches located on the outside of the seat cushion. Before driving, adjust the seat to the proper position so that you can easily control the steering wheel, foot pedals and controls on the instrument panel.

    WARNING

    NEVER allow children in the vehicle unattended. The power seats are operable when the vehicle is turned off.

    read more


     
    Copyright © 2025 www.hsafe4.com